Yamaha G29 Golf Cart Controller and Motor replacement
My Yamaha YDRE G29 Golf Cart stopped working. After troubleshooting the four main components (batteries, solenoid, controller, motor) and during a lot of online research... I incorrectly assumed the controller failed. After replacing the controller (Moric controllers #JW2-H6510-20) the Cart still didn't move. The batteries showed 48-50volts, the solenoid clicked when key turned and with the new controller... it had to be the motor. (At this time, BuggiesUnlimited website does not list the proper motor... it's the 7hp motor part #7115.) The motor is located above the rear right axle behind the passenger seat. The controller is in the center behind the seat and battery bank. Special note!!! In this configuration, the F1 wire goes to the F2 terminal and the F2 wire goes to the F1 terminal for correct polarity. If they are connected F1 to F1 etc.. then the cart will go in reverse when forward is selected and vice versa.

Common Yamaha Golf Cart Failures & How to Repair Them

How to test, wire and run a Series Wound motor!

Yamaha G29 Golf Cart Solenoid Replacement

Yamaha G29 5KW Install.

2003 Yamaha G22, 48 Volt Electric - Not Moving, Replace Solenoid

The most ridiculous worker fails caught on camera

Yamaha Golf Cart Won't Start? Here's How To Fix It

🚗 BYD : The biggest SCAM of the car industry ?

Unbelievable Smart Worker & Hilarious Fails | Construction Compilation #7 #adamrose #smartworkers

How To Test A Series Golf Cart Motor | Ezgo Club Car Yamaha

Yamaha Golf Cart G29. Will it Run?

THE Ultimate Yamaha 48V Golf Cart Troubleshooting Guide

How To Test Your Electric Motor In The Cart

Unbelievable Smart Worker & Hilarious Fails | Construction Compilation #8 #adamrose #smartworkers

electric golf cart, simple Motor and controller bypass key hotwire direct wire bench test

Bad Solenoid Causing Intermittent Starting Issues | Golf Cart Diagnosis

Yamaha Ignition Relay Stop Switch | G16 | G19 | G22 | G29 Drive Golf Cart

Golf Cart Motor Upgrade | Fix the noises

DIY: Install of Navitas 600 amp Controller and Solenoid on 2013 Yamaha G29 Drive golfcart

