Peugeot 308 1.6 HDI FULL Service Oil & Filter Air Fuel Cabin Filters Service Light Reset How To DIY

Here is the full service on the Peugeot 308 1.6 HDI diesel model years 2013, 2014, 2015, 2016, 2017, 2018, and 2019. If this video helps then please support me by subscribing and liking the video, thank you! Sump plug size is 21mm, torque requirement 34Nm Oil filter housing 27mm, torque requirement 25Nm Oil capacity 3.8 litres. Air filter: There are 3 T25 Torx screws along the front and a metal clip on the side that is easily done by hand. Make sure when fitting the new filter that the edges of the filter are definitely seated correctly. Fuel Filter: Remove the soundproof material on top of the engine. The fuel filter is located to the left hand side of the airbox/intake. Remove all the hoses and the electrical connector. There are 2x 8mm bolts at the rear and this will allow the top and filter to be removed from the car. Once you have removed the filter complete with the top if you lift the centre part by twisting this will allow the filter to be drained. Now remove the 3 T15 Torx screws. Now fit the top to the new filter making sure you replace the seal and fit completely square as the seal is easily dislodged. Push the centre down and replace the Torx screws. You can now refit to the car take care the bottom of the filter seats correctly, replace the hoses and electrical connector. Tighten the 8mm bolts. Cycle the ignition a few times as on a lot of cars this will allow the pre-delivery pump to fill the new filter. Now start the car and leave running for 5 minutes to make sure there's definitely no air. Cabin Filter: This is located in the drivers footwell on the right hand drive models just to the left of the clutch. Remove the kick panel insulation with Bojo Tip 3 then the side panel to the left of the clutch pedal. The filter is in 2 parts pull the tabs to remove. Refitting is the reversal of removal but make sure the new filters are pointing the correct way. They have a black arrow on and this should point to the rear of the car. If you'd like to support my channel please visit my websites and follow my socials: http://www.tolly.co.uk http://www.cleverproducts.co.uk/bojo-...   / tollyswift     / tolly_swift   Thanks!